پیوندهای مفید
آمار
| تعداد نشریات | 7 |
| تعداد شماره‌ها | 399 |
| تعداد مقالات | 5,389 |
| تعداد مشاهده مقاله | 5,288,194 |
| تعداد دریافت فایل اصل مقاله | 4,882,935 |
Fault Detection in Compression Refrigeration System with a Fixed Orifice and Rotary Compressor | ||
| AUT Journal of Mechanical Engineering | ||
| مقاله 11، دوره 4، شماره 2، شهریور 2020، صفحه 277-286 اصل مقاله (1.16 M) | ||
| نوع مقاله: Research Article | ||
| شناسه دیجیتال (DOI): 10.22060/ajme.2019.16081.5802 | ||
| نویسندگان | ||
| Seyed Ali Shamandi* 1؛ Saeid Rasouli2 | ||
| 1Young Researchers and Elite Club, Khomeinishahr Branch, Islamic Azad University, KhomeiniShahr, Isfahan, Iran | ||
| 2Islamic Azad University Khomeinishahr Branch, isfahan, iran | ||
| چکیده | ||
| In compression refrigeration systems such as air conditioning, chiller, split unit, which the refrigerant gas compression is used for cooling, the operation of the device is always dependent on parameters such as pressure, the temperature of different points, and consumed ampere. A tangible change in each of these items represents the existence of a potential fault in the cycle. The basic problem often arises from the fact that there is a time gap between the occurrence of fault and detection of it by the operator, causing damage to the device irreparably and the coefficient of performance is affected. Simulation has been performed by changing the refrigerant gas charge from 40% to 150%, causing condenser and evaporator clogging up to 30% and 60%, and also creating leakage in the compressor and fault detection and diagnosis is done with these parameters. In this paper, it is shown that a slight change in any of these parameters causes a change in the operation of the refrigeration cycle. In this study, Fault detection it was shown that the superheat value in refrigerant overcharge fault increasing to 16.5°C and in dirty condenser fault decreasing to 2.1°C and reduced evaporator air flow fault decreasing to 1.7°C. Also sub-cooling value in refrigerant undercharge, dirty condenser, reduced evaporator air flow, compressor failure fault decreasing to 4.2°C, 12.6°C, 12.8°C, 10°C. | ||
| کلیدواژه‌ها | ||
| Refrigeration system؛ Fault detection and diagnosis method؛ Capillary tube؛ Fault detection | ||
| مراجع | ||
|
[1] A.E. Outlook, Energy information administration, Department of Energy, 92010(9) (2010) 1-15.
[2] N. Kocyigit, H. Bulgurcu, C.-X. Lin, Fault diagnosis of a vapor compression refrigeration system with hermetic reciprocating compressor based on ph diagram, International journal of refrigeration, 45 (2014) 44-54.
[3] M. Stylianou, D. Nikanpour, Performance monitoring, fault detection, and diagnosis of reciprocating chillers, 0001-2505, American Society of Heating, Refrigerating and Air-Conditioning Engineers …, 1996.
[4] T.M. Rossi, J.E. Braun, A statistical, rule-based fault detection and diagnostic method for vapor compression air conditioners, Hvac&R Research, 3(1) (1997) 19-37.
[5] J.E. Braun, Automated fault detection and diagnostics for vapor compression cooling equipment, Journal of solar energy engineering, 125(3) (2003) 266-274.
[6] H. Han, B. Gu, T. Wang, Z. Li, Important sensors for chiller fault detection and diagnosis (FDD) from the perspective of feature selection and machine learning,International Journal of Refrigeration, 34(2) (2011) 586- 599.
[7] A. Janecke, T.J. Terrill, B.P. Rasmussen, A comparison of static and dynamic fault detection techniques for transcritical refrigeration, International Journal of Refrigeration, 80 (2017) 212-224.
[8] J. Choi, Y. Kim, Influence of the expansion device on the performance of a heat pump using R407C under a range of charging conditions, International Journal of Refrigeration, 27(4) (2004) 378-384.
[9] R. Holder. Charging Methods for Metering Devices, ACHR News, 2000 October 16.
[10] J.A. Siegel, An evaluation of superheat-based refrigerant charge diagnostics for residential cooling systems, (2002).
[11] N.S. Castro, Performance evaluation of a reciprocating chiller using experimental data and model predictions for fault detection and diagnosis/Discussion, ASHRAE Transactions, 108 (2002) 889.
[12] S. Tassou, I. Grace, Fault diagnosis and refrigerant leak detection in vapour compression refrigeration systems, International Journal of Refrigeration, 28(5) (2005) 680- 688.
[13] Z. Wang, L. Wang, K. Liang, Y. Tan, Enhanced chiller fault detection using Bayesian network and principal component analysis, Applied Thermal Engineering, 141 (2018) 898-905.
[14] G. Bogdanovská, V. Molnár, G. Fedorko, Failure analysis of condensing units for refrigerators with refrigerant R134a, R404A, International Journal of Refrigeration, 100 (2019) 208-219.
[15] F. Yu, G. Li, H. Chen, Y. Guo, Y. Yuan, B. Coulton, A VRF charge fault diagnosis method based on expert modification C5. 0 decision tree, International Journal of Refrigeration, 92 (2018) 106-112.
[16] Q. Mao, X. Fang, Y. Hu, G. Li, Chiller sensor fault detection based on empirical mode decomposition threshold denoising and principal component analysis, Applied Thermal Engineering, 144 (2018) 21-30.
[17] J. Liu, G. Li, B. Liu, K. Li, H. Chen, Knowledge discovery of data-driven-based fault diagnostics for building energy systems: A case study of the building variable refrigerant flow system, Energy, 174 (2019) 873-885.
[18] Y. Wang, Z. Wang, S. He, Z. Wang, A practical chiller fault diagnosis method based on Discrete Bayesian Network, International Journal of Refrigeration, (2019).
[19] B. Chen, J. Braun, Simple fault detection and diagnosis methods for packaged air conditioners, (2000).
[20] A. Handbook, Refrigeration, American Society of Heating, Refrigeration and Air Conditioning, (2006).
[21] M. Kim, M.S. Kim, Performance investigation of a variable speed vapor compression system for fault detection and diagnosis, International Journal of Refrigeration, 28(4) (2005) 481-488. | ||
|
آمار تعداد مشاهده مقاله: 851 تعداد دریافت فایل اصل مقاله: 1,096 |
||